动态荷载下纤维对胶结充填体的损伤破坏特性

Study on damage and failure characteristics of fiber on cemented paste backfill under dynamic loads

  • 摘要: 为探究动态荷载下聚丙烯纤维(PF)对胶结充填体损伤破坏特性的影响,通过制备不同灰砂质量比和纤维含量的胶结充填体试件(PFCPB),利用分离式霍普金森压杆(SHPB)试验装置和扫描电镜(SEM),分析了充填体试件在单次和循环冲击下的动态抗压强度,应力-应变曲线特征和充填体试件的宏观破坏形态及微观结构。研究发现充填体的动态抗压强度与平均应变率呈现正相关关系,掺入聚丙烯纤维可以有效地提高充填体的动态抗压强度,随着聚丙烯纤维含量的增加,充填体动态抗压强度呈现先增大后减小的趋势,较优掺量为0.6%,动态抗压强度提高了25%。结果表明,PF的加入显著提高了充填体的动态抗压强度和延性,且在循环冲击下,含PF充填体的抗冲击能力更强。在单次冲击和循环冲击实验中,随着PF含量增加,充填体的动态应力-应变曲线出现“多波峰”现象,峰值应力逐渐降低,峰后破坏阶段应力-应变曲线变得更平缓;单次冲击荷载下,充填体的破坏形态主要先表现为剪切破坏后再发生拉伸破坏,同一近似平均应变率下,裂纹扩展宽度随着纤维含量的增加先减小再增加,0.6PFCPB试件裂纹宽度最小;微观分析揭示了PF表面附着的水化产物C-S-H凝胶增强了PF与充填体基质的黏结力,有助于延缓微裂纹和微裂隙的扩展,提升充填体的力学性能。

     

    Abstract: To investigate the effect of polypropylene fiber (PF) on the damage and destruction characteristics of cemented paste backfill under dynamic loads, the dynamic compressive strength of the filler specimens under single and cyclic impacts, the stress-strain curve characteristics and the macroscopic damage morphology and microstructure of the filler specimens were analyzed by preparing cemented paste backfill specimens with different ash-to-sand ratios and fiber contents (PFCPB), using split Hopkinson pressure bar (SHPB) test setup and scanning electron microscopy (SEM), macro-damage morphology and microstructure of the filled body specimens. It is found that the dynamic compressive strength of the filled body shows a positive correlation with the average strain rate. The incorporation of polypropylene fibers (PPF) can effectively improve the dynamic compressive strength of the filled body, and with the increase of the content of PPF, the dynamic compressive strength of the filled body shows an increase and then a decrease, and the optimum dosage is 0.6%. The dynamic compressive strength is increased by 25%. The results show that adding PF significantly improves the filler’s dynamic compressive strength and ductility, and the PF-containing filler is more resistant to impact under cyclic impact. In the single impact and cyclic impact experiments, with the increase of PF content, the dynamic stress-strain curve of the filling body exhibits the phenomenon of “multiple peaks”, with the peak stress gradually reduced, and the stress-strain curve being smoother in the destructive stage after the peak. Under the single impact load, the damage pattern of the filling body is mainly manifested in the shear damage. Then, tensile damage and the same approximate average strain are shown as shear damage. Under a single impact load, the damage pattern of the filling body is mainly shear damage followed by tensile damage, and under the same approximate average strain rate, the crack expansion width decreases and then increases with the increase of fiber content, and the crack width of the 0.6PFCPB specimen is the smallest. The microscopic analysis reveals that the hydration product C-S-H gel attached to the surface of the PF strengthens the adhesion force between the PF and the matrix of the filling body, which can help to slow down the expansion of the microcracks and micro-fissures and improve the mechanical properties of the filling body.

     

/

返回文章
返回